[1]王现中,王仁超*.复杂山区煤矿采空区油气管道稳定性监测与数值分析[J].山地学报,2022,(3):411-420.[doi:10.16089/j.cnki.1008-2786.000681]
　WANG Xianzhong,WANG Renchao*.In-Situ Monitoring and Numerical Analysis of Oil and Gas Pipelines in Coal Seam Goaf Located in Mountainous Terrain[J].Mountain Research,2022,(3):411-420.[doi:10.16089/j.cnki.1008-2786.000681]
点击复制

复杂山区煤矿采空区油气管道稳定性监测与数值分析
分享到：

《山地学报》[ISSN:1008-2186/CN:51-1516]

卷:
期数:
2022年第3期
页码:
411-420
栏目:
山地灾害
出版日期:
2022-05-25

文章信息/Info

Title:
In-Situ Monitoring and Numerical Analysis of Oil and Gas Pipelines in Coal Seam Goaf Located in Mountainous Terrain
文章编号:
1008-2786-(2022)3-411-10
作者:
王现中1; 王仁超2*
1. 国家石油天然气管网集团有限公司华南分公司,广州 510620; 2. 电子科技大学 计算机科学与工程学院,成都 611731
Author(s):
WANG Xianzhong1;  WANG Renchao2*
1. South China Company of PipeChina, Guangzhou 510620, China; 2. School of Computer Science and Engineering, University of Electrionic Science and Technology of China, Chengdu 611731, China
关键词:
油气管道;  原位监测;  数值模拟;  煤矿采空区
Keywords:
oil-gas pipeline;  in situ monitoring;  numerical simulation;  goaf of coal mine
分类号:
TH822
DOI:
10.16089/j.cnki.1008-2786.000681
文献标志码:
A
摘要:
煤矿采空区引起地表沉降和塌陷,威胁采空区上方油气管道的安全。采用数值模拟方法可以分析煤矿或油气采空区不同工况条件下油气管道的力学性状,采用管道附着式传感器可以监测管道应力状态,但两类方法并未开展耦合分析,无法通过实时分析管道自身与周围土体共同作用下的形变与应力,反演管道完整性与岩土围压环境,也无法实现对油气长输管道运行状态动态监测与管理。本文采用原位监测与数值模拟相结合的方法,对遵义双田煤矿采空区上方的成品油管道开展了管道本体稳定性研究。结果表明:在监测周期内,监测区域孔隙水压随着降雨量的增加而增大,但变化幅度较小; 纵向位移整体呈增大趋势,但最大相对位移仅1.5 mm,地面沉降较小。基于原位监测进行数值模拟,得到的模拟结果与监测数据变化趋势相同,且模拟位移与监测位移变化范围相近,表明模拟结果较为准确。通过模拟结果分析,发现管道所受应力远小于临界值,推断管道处于稳定状态。但若煤矿处于开采状态,随着开采范围的增加,监测区域管道的轴向应力和剪应力急剧增大,当开挖范围超过40 m时,管道将处于失稳状态,极易发生破坏。本研究采用原位观测校核数值模拟结果的方法分析管道稳定性,基于该方法可指导穿越采空区油气管道的评估和预警工作。
Abstract:
Ground subsidence and collapse quite occurs in coal mine goaf, threatening the safety of oil-gas pipelines above the goaf. Although numerical simulation can be used to analyze the bearing behavior of oil-gas pipes under different loading cases in mined-out areas, and sensors attached to pipes are appliable to detect pipe stress state, there was not joint analysis available which combined the two methods. It was not advisable to estimate the integrity of oil-gas pipelines by analyzing the strain and stress of oil-gas pipe without inclusive of ambient geo-environment, such as overloading soil pressure, and further it also cannot realize the dynamic monitoring and management of the operation of long-distance oil-gas pipelines. In this paper, the stability of the oil-gas pipeline above the goaf of Shuangtian Coal Mine, Zunyi county, China was estimated by combining in-situ monitoring and numerical simulation. Results shows:(1)Within a monitoring cycle, the observed values of pore water pressure increased with the increase of rainfall, but their variation ranges were small; The longitudinal displacement tended to increase as a whole, with the maximum relative displacement only 1.5 mm, a small settlement.(2)The numerical simulation based on in-situ monitoring found a consistent change trend as compared with observation, for instance, the simulated displacement of ground subsidence similar to those from in-situ monitoring, suggesting that the simulation was reliable.(3)By simulation, it found that the stresses on a pipeline were far low than its critical value, referring to the pipelines in stable state; However, in case the coal mine was in the mining state, the axial stress and shear stress of the detected pipelines increased sharply with the increase of mining range; Once the excavation range exceeds 40 m, the pipeline came up to an unstable state and prone to damage. This study uses the method of checking numerical simulation with in-situ observations to analyze pipeline stability, which can guide the assessment and early warning of oil and gas pipelines crossing goaf.

参考文献/References:

[1] 高鹏. 2021年中国油气管道建设新进展[J]. 国际石油经济, 2022, 30(3): 12-19. [GAO Peng. New progress in China's oil and gas pipeline construction in 2021 [J]. International Petroleum Economics, 2022, 30(3): 12-19]
[2] GIRGIN S, KRAUSMANN E. Historical analysis of U.S. onshore hazardous liquid pipeline accidents triggered by natural hazards [J]. Journal of Loss Prevention in the Process Industries, 2016, 40: 578-590. DOI: 10.1016/j.jlp.2016.02.008
[3] 杜彩霞, 郭文朋, 申倬伟, 等. 煤矿采空区输气管道沉降防治技术研究[J]. 能源技术与管理, 2022, 47(3): 8-9+98. [DU Caixia, GUO Wenpeng, SHEN Zhuowei, et al. Research on prevention and control technology of gas pipeline settlement in goaf of coal mine [J]. Energy Technology and Management, 2022, 47(3): 8-9+98] DOI: 10.3969/j.issn.1672-9943.2022.03.003
[4] 石悦, 李朝, 郭文朋. 山西煤矿采空区天然气管道隐患治理探索与实践[J]. 油气田地面工程, 2020, 39(10): 38-42. [SHI Yue, LI Chao, GUO Wenpeng. Exploration and practice of hidden danger control of natural gas pipeline in mined-out area of Shanxi province [J]. Oil-Gas Field Surface Engineering, 2020, 39(10): 38-42] DOI: 10.3969/j.issn.1006-6896.2020.10.008
[5] 任建东, 王文, 董淼, 等. 开采沉陷区埋地管道变形及力学特征分析[J]. 中国安全科学学报, 2020, 30(10): 82-89. [REN Jiandong, WANG Wen, DONG Miao, et al. Analysis of deformation and mechanical characteristics of buried pipeline in mining subsidence areas [J]. China Safety Science Journal, 2020, 30(10): 82-89] DOI: 10.16265/j.cnki.issn1003-3033.2020.10.012
[6] 赵潇. 采空沉陷区埋地管道应力变形分析及远程监测[D]. 成都: 西南石油大学, 2015. [ZHAO Xiao. Stress and deformation analysis and remote monitoring of buried pipeline in goaf subsidence area [D]. Chengdu: Southwest Petroleum University, 2015]
[7] 荆和平. 山西煤矿采空区地层特征及勘察方法[J]. 地质灾害与环境保护, 2015, 26(1): 52-56. [JING Heping. Stratigraphic features and investigation methods of mine goafs in Shanxi [J]. Journal of Geological Hazards and Environment Preservation, 2015, 26(1): 52-56] DOI: 10.3969/j.issn.1006-4362.2015.01.010
[8] WANG Yuzhou, ZHOU Liangcheng. Spatial distribution and mechanism of geological hazards along the oil pipeline planned in western China [J]. Engineering Geology, 1999, 51(3): 195-201. DOI: 10.1016/s0013-7952(98)00036-2
[9] 赵应奎. 西气东输工程管道线路地质灾害及其防治对策[J]. 天然气与石油, 2002, 20(1): 44-48. [ZHAO Yingkui. The geological hazards and preventing and controlling measuresin the West-to-East Gas pipeline [J]. Natural Gas and Oil, 2002, 20(1): 44-48] DOI:10.3969/j.issn.1006-5539.2002.01.014
[10] 李云燕,赵万民. 西南山地城市雨洪灾害防治多尺度空间规划研究——基于水文视角[J]. 山地学报,2017,35(2):212-220. [LI Yunyan, ZHAO Wanmin. On the space planning of urban flood control on a multi-scale basis in the southwest mountain cities of China: Based on hydrological perspective [J]. Mountain Research, 2017, 35(2): 212-220] DOI: 10.16089/j.cnki.1008-2786.000214
[11] 王仁超,孔纪名,崔云. 西南山区长输油气管道坡面泥石流成灾特征与防治——以云南昆明水节箐高位溃决型泥石流为例[J]. 山地学报,2018,36(5): 813-820. [WANG Renchao, KONG Jiming, CUI Yun. Characteristics and countermeasures of slope debris flow in Kunming of Yunnan province of China [J]. Mountain Research, 2018, 36(5): 813-820] DOI: 10.16089/j.cnki.1008-2786.000377
[12] 郭守德, 王强, 林影, 等. 中缅油气管道沿线地质灾害分析与防治[J]. 油气储运, 2019, 38(9): 1059-1064. [GUO Shoude, WANG Qiang, LIN Ying, et al. Analysis and prevention of geological hazards along the China-Myanmar oil and gas pipeline [J]. Oil and Gas Storage and Transportation, 2019, 38(9): 1059-1064] DOI:10.6047/j.issn.1000-8241.2019.09.015
[13] 喻言家, 雍歧卫. 无人机油气管道巡线系统发展现状及建议[J]. 天然气与石油, 2017, 35(2): 22-25. [YU Yanjia, YONG Qiwei. Development status and suggestions of UAV oil and gas pipeline patrol system [J]. Natural Gas and Oil, 2017, 35(2): 22-25] DOI: 10.3969/j.issn.1006-5539.2017.02.005
[14] 郝晓平, 黄晓雯, 高志刚, 等. 无人机技术在油气管道巡护中的应用[J]. 油气储运, 2019, 38(8): 955-960. [HAO Xiaoping, HUANG Xiaowen, GAO Zhigang, et al. Application of unmanned aerial vehicle technology in patrolling oil/gas pipelines [J]. Oil and Gas Storage and Transportation, 2019, 38(8): 955-960] DOI: 10.6047/j.issn.1000-8241.2019.08.018
[15] YAN Yan, MA Shuyue, YIN Shuyao, et al. Detection and numerical simulation of potential hazard in oil pipeline areas based on UAV surveys [J]. Frontiers in Earth Science, 2021, 9: 665478. DOI: 10.3389/feart.2021.665478
[16] 卫小龙, 杜国锋, 袁洪强, 等. 超声导波在管道缺陷成像中的发展与挑战[J]. 科学技术与工程, 2021, 21(10): 3861-3867. [WEI Xiaolong, DU Guofeng, YUAN Hongqiang, et al. Development and challenge of ultrasonic guided waves in pipeline defect imaging [J]. Science Technology and Engineering, 2021, 21(10): 3861-3867] DOI: 10.3969/j.issn.1671-1815.2021.10.001
[17] 熊俊楠,曹依帆,孙铭,等. 基于GIS和熵权法的滑坡作用下的长输油气管道易损性评价[J]. 山地学报, 2020,38(5): 717-725. [XIONG Junnan, CAO Yifan, SUN Ming, et al. Vulnerability evaluation of long-distance oil and gas pipelines under landslide actions based on GIS and entropy weight method [J]. Mountain Research, 2020, 38(5): 717-725] DOI: 10.16089/j.cnki.1008-2786.000549
[18] 孙健, 马廷霞. 煤矿采空区管道监测方法的应用[J]. 管道技术与设备, 2012(3): 19-21. [SUN Jian, MA Tingxia. Application of pipeline monitoring method to goafs [J]. Pipeline Technology and Equipment, 2012(3): 19-21] DOI: 10.3969/j.issn.1004-9614.2012.03.008
[19] 李华章, 何文刚, 罗伟, 等. 天然气管道穿越煤矿采空区变形监测技术应用[J]. 山西建筑, 2021, 47(15): 69-71. [LI Huazhang, HE Wengang, LUO Wei, et al. Application of deformation monitoring technology for natural gas pipeline crossing goaf of coal mine [J]. Shanxi Architecture, 2021, 47(15): 69-71] DOI: 10.13719/j.cnki.1009-6825.2021.15.026
[20] 吴张中, 郝建斌, 谭东杰, 等. 采空塌陷区管土相互作用特征分析[J]. 中国地质灾害与防治学报, 2010, 21(3): 77-81. [WU Zhangzhong, HAO Jianbin, TAN Dongjie, et al. Characteristics of pipe-soil interaction in mining collapse areas [J]. The Chinese Journal of Geological Hazard and Control, 2010, 21(3): 77-81] DOI: 10.16031/j.cnki.issn.1003-8035.2010.03.026
[21] 白俊磊. 海底管道坠物碰撞损伤数值模拟分析研究[D]. 大连: 大连理工大学, 2013. [BAI Junlei. Numerical simulation and analysis of collision damage of submarine pipeline [D]. Dalian: Dalian University of Technology, 2013]
[22] 黄文, 谢锐, 陈小华. 落石冲击载荷下埋地油气管道力学分析[J]. 石油机械, 2019, 47(9): 138-144. [HUANG Wen, XIE Rui, CHEN Xiaohua. Mechanical analysis of buried oil and gas pipeline under rock fall impact [J]. China Petroleum Machinery, 2019, 47(9): 138-144] DOI:10.16082/j.cnki.issn.1001-4578.2019.09.021
[23] 蒋宏业, 王惠, 徐涛龙. 采空塌陷区埋地输气管道的变形及受力分析[J]. 中国安全生产科学技术, 2016, 12(2): 45-51. [JIANG Hongye, WANG Hui, XU Taolong. Analysis on deformation and stress of buried gas pipeline in mined-out subsidence area [J]. Journal of Safety Science and Technology, 2016, 12(2): 45-51] DOI: 10.11731/j.issn.1673-193x.2016.02.008
[24] 郑大海, 毛建, 赵冬野, 等. 地下采矿对埋地输气管道变形影响分析[J]. 成都大学学报(自然科学版), 2016, 35(3): 313-316. [ZHENG Dahai, MAO Jian, ZHAO Dongye, et al. Analysis of influence of underground mining on deformation of underground gas pipeline [J]. Journal of Chengdu University(Natural Science), 2016, 35(3): 313-316]
[25] 梁晓斌, 梁伟, 邓克飞, 等. 采空区悬空天然气管道应力与应变模拟[J]. 油气储运, 2019, 38(2): 145-150. [LIANG Xiaobin, LIANG Wei, DENG Kefei, et al. Simulation on the stress and strain of suspended gas pipelines in goafs [J]. Oil and Gas Storage and Transportation, 2019, 38(2): 145-150] DOI:10.6047/j.issn.1000-8241.2019.02.004
[26] 王海兰, 马廷霞, 徐洪敏, 等. X80输气管线悬空状态下的安全评价[J]. 科学技术与工程, 2014,14(34): 174-179+189. [WANG Hailan, MA Tingxia, XU Hongmin, et al. Safety evaluation of X80 gas transmission suspended pipelines [J]. Science Technology and Engineering, 2014,14(34): 174-179+189] DOI:10.3969/j.issn.1671-1815.2014.34.033
[27] 吴韶艳, 文宝萍. 采空区埋地油气管道变形数值模拟分析[J]. 安全与环境学报, 2014, 14(4): 87-91. [WU Shaoyan, WEN Baoping. Analysis of a numerical simulation on the deformation of inlaid pipeline in the mining-over areas [J]. Journal of Safety and Environment, 2014, 14(4): 87-91] DOI: 10.13637/j.issn.1009-6094.2014.04.021
[28] 张宏, 刘啸奔. 地质灾害作用下油气管道设计应变计算模型[J]. 油气储运, 2017, 36(1): 91-97. [ZHANG Hong, LIU Xiaoben. Design strain calculation model for oil and gas pipelines subject to geological hazards [J]. Oil and Gas Storage and Transportation, 2017, 36(1): 91-97] DOI: 10.6047/j.issn.1000-8241.2017.01.012
[29] 李平. 埋地油气管道地质灾害监测系统研究与应用[J]. 科技创新与应用, 2022, 12(2): 168-170. [LI Ping. Research and application of geological hazard monitoring system for buried oil and gas pipeline [J]. Technology Innovation and Application, 2022, 12(2): 168-170] DOI: 10.19981/j.CN23-1581/G3.2022.02.047
[30] 中国石油天然气股份有限公司.管道地质灾害识别与评估技术: GPIMS/00/FC007—2005(A)[S]. 2005.
[31] 中华人民共和国国家质量监督检验检疫总局,中国国家标准化管理委员会. 石油天然气工业管线输送系统用钢管:GB/T 9711—2017[S]. 2017-05-12.
[32] 中华人民共和国住房和城乡建设部,中华人民共和国国家质量监督检验检疫总局. 输油管道工程设计规范:GB 50253—2014. 2014-06-23.

备注/Memo

备注/Memo:
收稿日期(Received date):2022-04-29; 改回日期(Accepted date): 2022-06-22
基金项目(Foundation item):四川省科技计划重点研发项目(2022YFS0586); 广东省重点领域研发计划项目(2019B111102001)。[Key Research annd Development Program of Sichuan Province of China(2022YFS0586); Guangdong Key Area Research and Development Project(2019B111102001)]
作者简介(Biography):王现中(1978-),男,高级工程师,主要研究方向:成品油管道运营与管理工作。 [WANG Xianzhong(1978-), male, senior engineer, research on operation and management of refined oil pipeline] E-mail:wangxz03@pipechina.com.cn
*通讯作者(Corresponding author):王仁超(1989-),男,湖南湘潭人,博士,主要研究方向:山地灾害综合防治技术。 [WANG Renchao(1989-), male, born in Xiangtan, Hunan province, Ph.D., research on integrated prevention and control of mountain disasters ] E-mail: SupermanWang@uestc.edu.cn
更新日期/Last Update: 2022-06-30